Effect of Fly Ash Particle Reinforcement on Microstructure, Porosity and Hardness in Al-(Si-Mg) Cast Composites
نویسندگان
چکیده
منابع مشابه
the comparison of the microstructure and hardness of al-b and al-mg-b composites
aluminum base composite materials with variable properties which have been strengthened by alb 2 particles have been widely used. in this study, composites with variable properties of al-5%b and al-2%mg-2%b which are produced through centrifugal casting are investigated as far as their microstructure and hardness are concerned. the microstructure of these composite were studied by using metallo...
متن کاملDevelopment of in-Situ Al-Si/CuAl2 Metal Matrix Composites: Microstructure, Hardness, and Wear Behavior
In the present work, in-situ metal matrix composites were fabricated through squeeze casting. The copper particles were dispersed with different weight percentages (3%, 6%, 10%, and 15%) into Al-12% Si piston alloy. Also, heat treatments were performed at 380 °C and 450 °C for holding times of 6 and 18 h. The microstructures, X-ray diffractometer (XRD) pattern, hardness, and wear characteristic...
متن کاملWear behavior of Al-7%Si-0.3%Mg/melon shell ash particulate composites
The present study examined wear characteristics of A356/melon shell ash particulate composites. Dry-sliding the stainless steel ball against specimen disc revealed the abrasive wear behavior of the composites under loads of 2 and 5N. The composite showed lower wear rate of 2.182 × 10-4 mm3/Nm at 20 wt% reinforced material under load of 5N. Results showed that wear rate decreased significantly w...
متن کاملEffect of particle size and volume fraction on tensile properties of fly ash/polyurea composites
Fly ash, which consists of hollow particles with porous shells, was introduced into polyurea elastomer. A one-step method was chosen to fabricate pure polyurea and the polyurea matrix for the composites based on Isonate® 2143L (diisocyanate) and Versalink® P-1000 (diamine). Scanning electron microscopy was used to observe the fracture surfaces of the composites. Particle size and volume fractio...
متن کاملPorosity Effect on Thermal Properties of Al-12 wt % Si/Graphite Composites
The effect of porosity on the thermal conductivity and the coefficient of thermal expansion of composites obtained by infiltration of Al-12 wt % Si alloy into graphite particulate preforms has been determined. Highly irregular graphite particles were used to fabricate the preforms. The thermal conductivity of these composites gradually increases with the applied infiltration pressure given the ...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ژورنال
عنوان ژورنال: ASEAN Journal on Science and Technology for Development
سال: 2007
ISSN: 0217-5460
DOI: 10.3125/asean.v23i1.413