Interactions between Automotive Shredder Residue and Olivine Bed Material during Indirect Fluidized Bed Gasification
نویسندگان
چکیده
Thermal conversion of automotive shredder residue (ASR) using indirect fluidized bed gasification was conducted in the Chalmers semi-industrial 2–4-MWth gasifier. The material consisted olivine that activated through deposition biomass ash prior to a 13-day exposure ASR. interactions between and ASR were investigated XRD, SEM-EDS, thermodynamic modeling. iron (Fe) onto particles noted, this is likely increase oxygen-carrying ability particles. Furthermore, at end campaign, about one-third found originate from ash. These rich Fe Si, as well elements exclusively ash, such Zn, Ti, Cu. Some these exhibited hollow morphology, suggesting melt state during their formation In addition, low level agglomeration detected. Thermodynamic modeling with FactSage software indicated slag. This study presents detailed investigation occur an ash-rich fuel findings may have applications demonstrating induction materials or for metal recycling separation material.
منابع مشابه
Mass balance for POPs in a real scale fluidized bed combustor co-incinerating automotive shredder residue.
The European directive 2000/53/EC implies a "reuse and recovery" rate for end-of-life vehicles (ELVs) of 95% to be reached by the year 2015. One of the options to increase the actual average European "reuse and recovery" rate of approximately 78% (EU 15, 2008) is incineration of automotive shredder residue (ASR) with energy-recovery. The mass balance and the congener fingerprints for PCDD/Fs, d...
متن کاملEffect of Fe-olivine on the tar content during biomass gasification in a dual fluidized bed
متن کامل
Biomass Gasification in Fluidized Bed Gasifiers Modeling and Simulation
Using woody biomass as a resource for production of biofuel, heat and power through gasification has been studied for years. In order to reduce the cost of operating and to design the full-scale gasification plant developing a general model to be applicable for different ranges of input data with acceptable level of accuracy, is needed. In order to develop such model for the gasifier, as the ma...
متن کاملBiomass gasification with NiO/Olivine catalysts in fluidised bed gasifier
Tar removal from biomass gasification gas is a crucial problem in applying syngas from biomass for its downstream applications. Catalytic biomass gasification has given promising results for tar cracking. A few research groups have investigated the use of olivine for tar cracking [2,3,4,7,8,9,10]. The presence of oxides of iron and magnesium in the mineral olivine give it the ability to crack h...
متن کاملFluidized-bed gasification of dairy manure by Box-Behnken design.
Application of excessive animal manure to the land may cause some environmental problems such as eutrophication of surface waters, degradation of ground water quality, and threats to human health. This paper reports an experimental study on the technology of biomass gasification to treat animal waste by analysing the effects of key operating parameters on gasification. In this research, dairy m...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ژورنال
عنوان ژورنال: Energy & Fuels
سال: 2021
ISSN: ['1520-5029', '0887-0624']
DOI: https://doi.org/10.1021/acs.energyfuels.1c02137