Phase equilibria and simulation method for heterogeneous azeotropic distillation.
نویسندگان
چکیده
منابع مشابه
Dividing wall columns for heterogeneous azeotropic distillation
The aim of this work is to implement heterogeneous azeotropic distillation schemes in a dividing wall column (DWC) for a feed mixture of water (W), acetic acid (HAC) and an organic component (X). The original design makes use of X to act as an entrainer to facilitate the separation of water and HAC, and we also propose a DWC design based on this idea. This DWC design reduces the capital cost, b...
متن کاملSimulation of Heterogeneous Azeotropic Distillation Process with a Non-equilibrium Stage Model
A rate-based simulation method is developed with the correlation for mass transfer rate, which was obtained in our experiments of the homogeneous and heterogeneous ternary distillation with a sieve tray column. The simulation method is applied to the process of ethanol dehydration with benzene, which consists of a dehydrationand an entrainer recovery column. In the simulation study, the effect ...
متن کاملOptimal Design Methodology for Azeotropic Distillation Columns
We develop a short and optimal design methodology for multicomponent mixtures, based on the concept of minimum difference in composition. The minimum reflux ratio is calculated through an analytical procedure, which allowing their use in multicomponent mixtures. The procedure also includes a simple criterion to optimize the structural design of the column, without increasing energy consumption....
متن کاملBK1064-ch68_R2_250706 PRESSURE SWING BATCH DISTILLATION FOR HOMOGENOUS AZEOTROPIC SEPARATION
The separation of the homogeneous azeotropic mixture acetonitrile/water by pressure swing distillation (PSD) is considered. The PSD is operated as a discontinuous (batch) process and two batch modes, regular and inverted, are considered. The processes are analysed, aspects as to which batch mode should be preferred are discussed, and a dynamic model for both batch PSD processes is formulated. T...
متن کاملPressure Swing Distillation Simulation and Optimization of Azeotropic IBA + IBAc Mixture
The present work is to simulate and analyze pressure-swing distillation process for azeotropic IBA-IBAc separation using CHEMCAD simulation software. The total number of feed plates, reflux ratio in first column and total number of plates, operating pressure and the feed stream concentration of IBA for the second column are varied to find the optimum feed plate location, to get the desired outp...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ژورنال
عنوان ژورنال: JOURNAL OF CHEMICAL ENGINEERING OF JAPAN
سال: 1993
ISSN: 0021-9592,1881-1299
DOI: 10.1252/jcej.26.41