Synthesis of Silicon Nitride Ceramic Material using Direct Nitridation Process
نویسندگان
چکیده
منابع مشابه
MICROSTRUCTURAL STUDY OF SILICON NITRIDE WHISKERS PRODUCED BY NITRIDATION OF PLASMA-SPRAYED SILICON LAYERS
plasma-sprayed silicon layers have been used to produce silicon nitride layers with fibrous microstructure which optimizes fracture toughness and strength. SEM examination of the specimens shows that the surface is covered by fine needles and whiskers of Si3N4.In order to study the oxygen contamination effect as well as other contaminants introduced during spraying and nitridation processes, su...
متن کاملSynthesis of gallium nitride nanostructures by nitridation of electrochemically deposited gallium oxide on silicon substrate
Gallium nitride (GaN) nanostructures were successfully synthesized by the nitridation of the electrochemically deposited gallium oxide (Ga2O3) through the utilization of a so-called ammoniating process. Ga2O3 nanostructures were firstly deposited on Si substrate by a simple two-terminal electrochemical technique at a constant current density of 0.15 A/cm(2) using a mixture of Ga2O3, HCl, NH4OH ...
متن کاملCatalytic Effects of Cr on Nitridation of Silicon and Formation of One-dimensional Silicon Nitride Nanostructure
The catalytic effects of chromium (Cr) on the direct nitridation of silicon (Si) and morphology of nitridation product were investigated. Cr dramatically improved the conversation of Si to silicon nitride (Si3N4). The complete conversion was achieved at 1350 °C upon addition of 1.25 wt% Cr. This temperature was much lower than that required in the case without using a catalyst. Meanwhile, Cr pl...
متن کاملSpontaneous direct bonding of thick silicon nitride
Wafers with 1 μm LPCVD silicon-rich nitride layers have been successfully direct bonded to silicon-rich nitride and boron-doped silicon surfaces. A chemical–mechanical polishing treatment was necessary to reduce the surface roughness of the nitride before bonding. The measured surface energies of the room-temperature bond were comparable to values found for Si–Si hydrophilic bonding. A mechanis...
متن کاملDirect Synthesis of α-Silicon Nitride Nanowires from Silicon Monoxide on Alumina
Silicon nitride nanowires were synthesized using silicon monoxide as raw materials and an alumina plate as substrate at 1500°C. The obtained nanowires were characterized by X-ray diffraction, Fourier transform infrared spectrosco‐ py, scanning electron microscopy, high-resolution trans‐ mission electron microscopy and thermogravimetricdifferential scanning calorimetry. The results revealed that...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ژورنال
عنوان ژورنال: International Journal of Advanced Engineering Research and Science
سال: 2018
ISSN: 2349-6495,2456-1908
DOI: 10.22161/ijaers.5.8.14