Rice Grain Moisture Determination Using Microstrip Wide- Ring and Microstrip Coupled-Line Sensors
نویسندگان
چکیده
Corresponding Author: Kok Yeow You, Department of Radio Communication Engineering, Faculty of Electrical Engineering, Universiti Teknologi Malaysia, Malaysia Email: [email protected] Abstract: Determining the Moisture Content (MC) inside rice grain is an important element for grain processesing such as harvesting, storage, quality control and transportation. A microstrip wide-ring sensor and a microstrip coupled-line sensor with low insertion loss were developed to operate at relatively low frequency to determine the MC and relative complex permittivity of rice grain. The complex permittivity for rice grain with various moisture levels was measured by the proposed sensors based on the resonance technique. Calibration equations for measurement of grain MC were obtained and validated with white rice for MC ranging from 10 to 28% wet basis. The coupled-line sensor showed better sensitivity to moisture measurement as compared to the wide-ring sensor. For a 1% change in MC, the changes of resonant frequency for the wide-ring and coupled-line sensors were 4.36 and 10.69 MHz respectively. Meanwhile, the wide-ring sensor had a higher accuracy in MC prediction than the coupled-line sensor. The average errors in moisture prediction for wide-ring and coupled-line sensors were 0.85 and 1.30% respectively.
منابع مشابه
Analysis of Moisture Sensor Based on Microstrip Patch Antenna: a Review
The paper summarize that moisture sensor based on microstrip patch antenna. Microstrip patch sensors have become useful and widely used in every fields such as agricultures, industrials, food products, medicals communication etc. It have been more useful for detecting i.e., broken rice detection, Impurities detection in water, Soil moisture measurement, Rice Grain moisture, Rice quality detecti...
متن کاملFrequency Optimization for Dynamic Measurements of Wide-range Moisture Content using Microwave
This paper describes dynamic and static measurement methods for wide-range moisture content of agricultural products such as rice and silage. The proposed method uses the attenuation and phase shift of the microwave transmitted signal through a microstrip transmission line (MSTL) sensor. The results of dynamic measurements of rice samples with low moisture content(< 18 %) showed close agreement...
متن کاملThe analysis and design of multi-layer microstrip moisture sensor for rice grain ABSTRACT The analysis and optimal design of a multi-layered microstrip sensor for measuring moisture content of ricegrain
The analysis and optimal design of a multi-layered microstrip sensor for measuring moisture content of ricegrain are described. The microstrip sensing structure consists of three layers: substrate, protective layer and semi-infinite grain medium. The effective dielectric constant, characteristic impedance and attenuation or insertion loss of this structure are calculated at various moisture con...
متن کاملMoisture Content Detection Based on Transmission Power Measurement Using a Microstrip Wide-Ring Sensor
متن کامل
Microstrip ring resonator for soil moisture measurements
Accurate determination of spatial soil moisture distribution and monitoring its temporal variation have a significant impact on the outcomes of hydrologic, ecologic, and climatic models. Development of a successful remote sensing instrument for soil moisture relies on the accurate knowledge of the soil dielectric constant ( soil) to its moisture content. Two existing methods for measurement of ...
متن کامل