Design and Optimization of a Rotary Actuator for a Two Degree-of-Freedom zφ-Module
نویسنده
چکیده
The paper concerns the design and optimization of a rotary actuator which is applied in a pick-and-place robot. The rotary actuator is part of a zφ-module and provides ±180°rotation. The rotor of this actuator is attached to a linear actuator which offers a z-motion of ±5 mm. In the paper, the optimal combinations of magnet poles and coils are determined for this slotless actuator with concentrated windings. Based on this analysis, of the rotary actuator is optimized using a multiphysical framework, which contains a coupled electromagnetic, mechanical and thermal model. Because the rotation angle is limited, both a moving coil design with a double mechanical clearance and a moving magnet design with a single mechancial clearance have been investigated and compared. Additionally, the influence of the edge effects of the magnets on the performance of the rotary actuator has been investigated with both 3D FEM simulations and measurements.
منابع مشابه
Pareto Optimization of a Two-degree of Freedom Passive Linear Suspension Using a New Multi-objective Genetic Algorithm (TECHNICAL NOTE)
The primary function of a suspension system of a vehicle is to isolate the road excitations experienced by the tires from being transmitted to the passengers. In this paper, we formulate an optimal vehicle suspension design problem with the quarter-car vehicle dynamic model. A new multi-objective genetic algorithm is used for Pareto optimization of a two-degree of freedom vehicle vibration mode...
متن کاملDirect adaptive fuzzy control of flexible-joint robots including actuator dynamics using particle swarm optimization
In this paper a novel direct adaptive fuzzy system is proposed to control flexible-joints robot including actuator dynamics. The design includes two interior loops: the inner loop controls the motor position using proposed approach while the outer loop controls the joint angle of the robot using a PID control law. One novelty of this paper is the use of a PSO algorithm for optimizing the contro...
متن کاملA Robust Adaptive Observer-Based Time Varying Fault Estimation
This paper presents a new observer design methodology for a time varying actuator fault estimation. A new linear matrix inequality (LMI) design algorithm is developed to tackle the limitations (e.g. equality constraint and robustness problems) of the well known so called fast adaptive fault estimation observer (FAFE). The FAFE is capable of estimating a wide range of time-varying actuator fault...
متن کاملOscillation Control of Aircraft Shock Absorber Subsystem Using Intelligent Active Performance and Optimized Classical Techniques Under Sine Wave Runway Excitation (TECHNICAL NOTE)
This paper describes third aircraft model with 2 degrees of freedom. The aim of this study is to develop a mathematical model for investigation of adoptable landing gear vibration behavior and to design Proportional Integration Derivative (PID) classical techniques for control of active hydraulic nonlinear actuator. The parameters of controller and suspension system are adjusted according to be...
متن کاملSimulation of Human Foot Mechanism with a Degree of Freedom Motion
The need for simulation of human foot mechanism has made researchers and engineers move towards different patterns to describe this movement. In this regard, optimal solutions such as energy consumption, accuracy, etc. are of utmost importance. In this paper, efforts have been made to present a new solution by designing a fully two-dimensional six-bar mechanism with one degree of freedom so tha...
متن کامل