Plasma Characteristics Using Superimposed Dual Frequency Inductively Coupled Plasma Source for Next Generation Device Processing.
نویسندگان
چکیده
U-shaped inductively coupled plasma (ICP) source was investigated as a linear plasma source for the next generation roll-to-toll flexible display processing. For the radio frequency power to the source, the dual frequency composed of 13.56 MHz and 2 MHz was used and the effect of dual frequency to the U-shaped ICP source on the plasma density, electron temperature, and plasma uniformity was investigated. As the operating condition, 200 mTorr Ar was used without operating turbo pumps. The use of superimposed dual frequency composed of 13.56 MHz + 2 MHz instead the single frequency of 13.56 MHz increased the plasma density slightly at the same total power. In addition, the addition of 2 MHz rf power to 0.4 kW while maintaining 1 kW 13.56 MHz rf power not only decreased electron temperature but also improved both the plasma uniformity and the process uniformity measured by photoresist etching. Therefore, by using the dual frequency to the U-shaped ICP source, not only the plasma density but also plasma uniformity could be improved in addition to the decrease of possible damage to the substrate.
منابع مشابه
Nonlinear Dynamics of Radio Frequency Plasma Processing Reactors Powered by Multifrequency Sources
The source frequency has a strong influence on plasma characteristics in RF discharges. Multiple sources at widely different frequencies are often simultaneously used to separately optimize the magnitude and energy of ion fluxes to the substrate. In doing so, the sources are relatively independent of each other. These sources can, however, nonlinearly interact if the frequencies are sufficientl...
متن کاملStudy of RF Source Ignition System with Impedance Matching Network for RF Driven H
This paper presents study of a 6.78 MHz RF source with impedance matching network based inductively coupled plasma generator ignition system for an Hion source. Two types of 10 turn RF antenna (solenoid coil) were developed, to couple the RF power to the ignition plasma chamber. The antenna’s electric parameters were measured using Vector Network Analyzer (VNA). A copper conductor of 3 x 4 mm s...
متن کاملScreening and Optimization of Microextraction of Pb(II) by Inductively Coupled Plasma-Atomic Emission Using Response Surface Methodology
Dispersive liquid–liquid microextraction (DLLME) combined with inductively coupled plasma-atomic emission spectrometry (ICP-AES) was applied for the determination of lead in different environmental water samples. Ammonium pyrrolidine dithiocarbamate (APDC), chloroform and ethanol were used as chelating agent, extraction solvent and disperser solvent, respectively. The effective parameters, such...
متن کاملSelective Separation and Preconcentration of trace Amounts of Gallium in Water and Rice Samples using Cloud Point Extraction and Determination by Inductively Coupled Plasma-Atomic Emission Spectrometry
In the present study a cloud-point extraction process using non-ionic surfactant Triton X-114 for selective extraction of gallium from aqueous solutions was developed. The method is based on the complex formation of Ga (III) with N, N′ -bis (salycilidene)-1, 2-phenylenediamine (salophen) as a chelating agent in buffer media of pH 5. After phase separation and dilution of the surfactant-rich pha...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
عنوان ژورنال:
- Journal of nanoscience and nanotechnology
دوره 15 11 شماره
صفحات -
تاریخ انتشار 2015