Wavelet Analysis And Envelope Detection For Rolling Element Bearing Fault Diagnosis A Comparative Study
نویسنده
چکیده
Envelope Detection (ED) is traditionally always used with Fast Fourier Transform (FFT) to identify the rolling element bearing faults. The inability of FFT to detect non-stationary signals makes Wavelet Analysis (WA) an alternative for machinery fault diagnosis as WA can detect both stationary and non-stationery signals. A comparative study of ED with FFT and WA techniques for bearing fault diagnosis is presented in this report and it is shown with help of experimental results that the WA is a better fault diagnostic tool.
منابع مشابه
A DWT and SVM based method for rolling element bearing fault diagnosis and its comparison with Artificial Neural Networks
A classification technique using Support Vector Machine (SVM) classifier for detection of rolling element bearing fault is presented here. The SVM was fed from features that were extracted from of vibration signals obtained from experimental setup consisting of rotating driveline that was mounted on rolling element bearings which were run in normal and with artificially faults induced conditio...
متن کاملFault Diagnosis Method Based on Kurtosis Wave and Information Divergence for Rolling Element Bearings
Fault diagnosis depends largely on feature analysis of vibration signals. However, feature extraction for fault diagnosis is difficult because the vibration signals often contain a strong noise component. Noises stronger than the actual fault signal may interfere with diagnosis and ultimately cause misdiagnosis. In order to extract the feature from a fault signal highly contaminated by the nois...
متن کاملRolling Bearing Fault Analysis by Interpolating Windowed DFT Algorithm
This paper focuses on the problem of accurate Fault Characteristic Frequency (FCF) estimation of rolling bearing. Teager-Kaiser Energy Operator (TKEO) demodulation has been applied widely to rolling bearing fault detection. FCF can be extracted from vibration signals, which is pre-treatment by TEKO demodulation method. However, because of strong noise background of fault vibration signal, it is...
متن کاملDiagnosis of Rolling Element Bearing Fault in Bearing-gearbox Union System Using Wavelet Packet Correlation Analysis
The failure of rotating machinery sometimes involves several faulty components. Existence of both bearing fault and gearbox fault is widely observed and in this situation the vibration feature of the bearing fault can be masked by the faulty gearbox vibration signals. In this research, a method is proposed based on wavelet packet transform and envelope analysis to extract fault features of the ...
متن کاملIncipient fault diagnosis of rolling element bearing based on wavelet packet transform and energy operator
This paper mainly deals with the issue of incipient fault diagnosis for rolling element bearing. Firstly, an envelope demodulation technique based on wavelet packet transform and energy operator is applied to extract the fault feature of vibration signal. Secondly, the relative spectral entropy of envelope spectrum and the gravity frequency are combined to construct two-dimensional features vec...
متن کامل