Analysis of Changes on Mean Particle Size in a Fluidized Bed using Vibration Signature
نویسندگان
چکیده مقاله:
Vibration signals were measured in a lab-scale fluidized bed to investigate the changes in particle sizes. Experiments were carried out in the bed with a different mass fraction of coarser particles at different superficial gas velocities, and probe heights. The S-statistic test evaluates the dimensionless squared distance between two attractors reconstructed from time series of vibration signals. Values of parameters needed for the attractor reconstruction were derived from time series. These parameters consist of time delay, embedding dimension, bandwidth, and segment length with the values of 1, 35, (0.4-0.8), and (300-400), respectively. To reduce the sensitivity of the S-statistic to small changes in superficial gas velocities, the vibration signals were normalized in order to apply the attractor comparison test. The results showed that the attractor comparison can be a reliable technique for detecting particles size changes in fluidized beds even with small changes in the amount of coarser particles. The sensitivity of the method to particle size changes was decreased with an increase in superficial gas velocity. The results also show that the S-statistic test was almost independent of the measurement position of the vibration signals.
منابع مشابه
Bubble formation on a single orifice in a gas solid fluidized bed using digital image analysis
Digital Image Analysis (DIA) has been employed to characterize the time evolution of a bubble injected from a single orifice into a pseudo 2-dimansional gas-solid fluidized bed. The injected bubble diameter increased with the square root of time before detachment. During bubble free flight in the bed, its diameter remains approximately constant. The center of mass of the bubble increases with t...
متن کاملHydrodynamics of a Gas-Solid Fluidized Bed at Elevated Temperatures Using the Radioactive Particle Tracking Technique
Effect of temperature on hydrodynamics of bubbling gas-solid fluidized beds was investigated. Experiments were carried out in the range of 25-600 ºC and different superficial gas velocities in the range of 0.17-0.78 m/s with sand particles. Time-position trajectory of particles was obtained by radioactive particle tracking technique. These data were used for determination of mean velocitie...
متن کاملvibration effect on particle bed aerodynamic behavior and thermal performance of black tea in fluidized bed dryers
black tea sample was dried by a vibro-fluidized bed dryer to find its aerodynamic behavior and thermal performance during drying. the drying experiments were conducted at three different inlet air temperatures of 100, 115 and 130°c and fluidization condition at five vibration intensity levels of 0 (no vibration), 0.063, 0.189, 0.395 and 1.184. the results showed that bed channeling and defluidi...
متن کاملOnline Detection of Hydrodynamic Changes in Fluidized Bed using Cross Average Diagonal Line
Online detection of hydrodynamics of gas-solid fluidized bed was characterized using pressure fluctuations by cross recurrence plot (CRP) and cross recurrence quantification analysis (CRQA). Experiments were conducted in a lab scale fluidized bed of various particle sizes 150 μm, 280 μm and 490 μm at different gas velocities. Firstly, pattern changes of cross recurrence plot were discussed and ...
متن کاملمنابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ذخیره در منابع من قبلا به منابع من ذحیره شده{@ msg_add @}
عنوان ژورنال
دوره 53 شماره 1
صفحات 123- 135
تاریخ انتشار 2019-06-01
با دنبال کردن یک ژورنال هنگامی که شماره جدید این ژورنال منتشر می شود به شما از طریق ایمیل اطلاع داده می شود.
میزبانی شده توسط پلتفرم ابری doprax.com
copyright © 2015-2023