Experimental Investigation of Flooding and Drop Size in a Kuhni Extraction Column
نویسندگان
چکیده مقاله:
In this research, Sauter-mean drop diameters and the flooding behavior have been investigated experimentally in a pilot scale Kühni extraction column. The experiments were carried out in the absence of mass transfer for two different standard chemical systems. In the experiments operating parameters including agitation speed, flow rate of both liquid phases and interfacial tension have been studied. The results showed that Sauter-mean diameter are strongly affected by agitation speed and interfacial tension but the effects of continuous phase and dispersed phase flow rates are negligible. An empirical correlation for prediction of mean drop size as a function of column geometry, operating conditions and physical properties of liquid systems is suggested with a mean deviation of 9.54 %. Flooding rate is also influenced mainly by rotor speed and interfacial tension. An empirical correlation for predicting flooding velocities is also proposed with a mean deviation of 11.54 %.
منابع مشابه
Modelling of Mean Drop Size in a Extraction Spray Column and Developing a New Model
In the present investigation the biosorption potential of rosa gruss an teplitz (Red Rose) Waste Biomass (RRWB) for the removal of Pb(II) and Co(II) from aqueous solutions was studied. The effect of different process parameters such as pH, biosorbent dose, biosorbent size, temperature, contact time, initial metal concentration and pretreatments on the biosorption capacity of this waste biom...
متن کاملInvestigation of Packing Effect on Mass Transfer Coefficient in a Single Drop Liquid Extraction Column
متن کامل
modelling of mean drop size in a extraction spray column and developing a new model
in the present investigation the biosorption potential of rosa gruss an teplitz (red rose) waste biomass (rrwb) for the removal of pb(ii) and co(ii) from aqueous solutions was studied. the effect of different process parameters such as ph, biosorbent dose, biosorbent size, temperature, contact time, initial metal concentration and pretreatments on the biosorption capacity of this waste biomass ...
متن کاملExperimental Investigation of Phase Inversion of Liquid-Liquid Systems in a Spray Extraction Column
An experimental study of the phase inversion behavior of liquid-liquid dispersion has been conducted in a spray extraction column for systems of toluene / water, n-hexane/water, CCl4/water, toluene /water + glycerol (25 % wt), toluene + CCl4 (25 % wt) / water and toluene / acetic acid (5 % wt)/water. The effects of physical properties, mass transfer and column geometry...
متن کاملModeling and Simulation of Kuhni Extraction Column Using a Rate-based Model
In this study, liquid-liquid extraction process in a Kuhni extraction column was modeled and simulated. A non-equilibrium dynamic model was developed for modeling liquid-liquid extraction processes based on a rate-based model. The model equations are inclusive of partial and ordinary differential equations which were discretized in column height direction. The population balance model was used ...
متن کاملمنابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ذخیره در منابع من قبلا به منابع من ذحیره شده{@ msg_add @}
عنوان ژورنال
دوره 29 شماره 3
صفحات 288- 296
تاریخ انتشار 2016-03-01
با دنبال کردن یک ژورنال هنگامی که شماره جدید این ژورنال منتشر می شود به شما از طریق ایمیل اطلاع داده می شود.
کلمات کلیدی
میزبانی شده توسط پلتفرم ابری doprax.com
copyright © 2015-2023