Design a prototype reactor for fuel oil production from waste tires using pyrolysis process
نویسندگان
چکیده
منابع مشابه
Steam Reforming and Gasification of Pyrolysis Oil Reactor and Process Development for Syngas Production from Biomass
Gasification of pyrolysis oil was studied in a fluidized bed over a wide temperature range (523-914 °C) with and without the use of nickel-based catalysts. Noncatalytically, a typical fuel gas was produced. Both a special designed fluid bed catalyst and a crushed commercial fixed bed catalyst showed an initial activity for syngas (H2 and CO) production at T >700 °C. However, these catalysts los...
متن کاملVacuum pyrolysis of waste tires with basic additives.
Granules of waste tires were pyrolyzed under vacuum (3.5-10 kPa) conditions, and the effects of temperature and basic additives (Na2CO3, NaOH) on the properties of pyrolysis were thoroughly investigated. It was obvious that with or without basic additives, pyrolysis oil yield increased gradually to a maximum and subsequently decreased with a temperature increase from 450 degrees C to 600 degree...
متن کاملEstimation of pyrolysis product of LDPE degradation using different process parameters in a stirred reactor
Pyrolysis of low density polyethylene (LDPE) by equilibrium fluid catalytic cracking (FCC) was studied in a stirred reactor under different process parameters. In this work, the effect of process parameters such as degradation temperature (420-510°C), catalyst/polymer ratio (0-60%), carrier gas type (H2, N2, ethylene, propylene, Ar and He), residence time and agitator speed (0-300 rpm) on the c...
متن کاملSingle Step and Non-Catalytic Process for Formaldehyde Production from Methane using Microchannel Reactor: Theoretical Analysis
Conventionally, methane is reformed into syngas, and subsequently converted into C1-oxygenates (methanol and formaldehyde). A novel option is the catalyst-free single-step conversion of methane to C1-oxygenates. This study presents a comprehensive model of methane partial oxidation to formaldehyde as an intermediate chemical species in methane oxidation process using microreactor. The dependenc...
متن کاملBiodiesel production from canola oil using ultrasonic reactor in small scale circulation process
Currently, most of the biodiesel is produced from vegetable oils and methanol in the presence of base catalysts using mechanical stirring method at temperature 50-65C. This method consumes much energy because oils and methanol must be heated up to desired temperature, and also requires rather long reaction time. Ultrasound-assisted reaction can reduce the reaction time much shorter than mechani...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ژورنال
عنوان ژورنال: Egyptian Journal of Chemistry
سال: 2019
ISSN: 2357-0245
DOI: 10.21608/ejchem.2019.4682.1412