Film Formation and Anticorrosive Behavior of Zn-ZSM-5 Nano-Sized Zeolite Composite Coatings
نویسندگان
چکیده
The zincZeolite Socony Mobil-Five nano-particles (Zn-ZSM-5 NPs) composite was prepared and applied successfully as a new coating material to improve the corrosion resistance of steel. The corrosion type and quality of both pure zinc and our new coating material, Zn-ZSM-5 NPs, were studied using mass loss, impedance and electro-chemical polarization techniques in a sodium chloride solution. Obtained results affirm that Zn-ZSM-5 NPs are non-permeable and their corrosion resistance is higher than the pure zinc. The surface morphology of our newly synthesized coating material, Zn-ZSM-5 NPs, was investigated using SEM and X-ray diffraction and the smaller grain size was observed in comparison with the pure zinc coating. Keyword: Zeolite Socony Mobil-Five (ZSM-5), Zeolite nano-particles, Corrosion, Composite coating, zinc.
منابع مشابه
Strategies to Enhance the Catalytic Performance of ZSM-5 Zeolite in Hydrocarbon Cracking: A Review
ZSM-5 zeolite is widely used in catalytic cracking of hydrocarbon, but the conventional ZSM-5 zeolite deactivates quickly due to its simple microporous and long diffusion pathway. Many studies have been done to overcome these disadvantages recently. In this review, four main approaches for enhancing the catalytic performance, namely synthesis of ZSM-5 zeolite with special morphology, hierarchic...
متن کاملFacile synthesis of nano-sized hollow single crystal zeolites under mild conditions.
We report a method to synthesize hollow ZSM-5 single crystals of a size below 100 nm that could function as nanoreactors with access through the zeolite micropores only. In the first step, ZSM-5 is synthesized with the respective crystal size. In the second, the zeolite is base leached and acid washed under mild conditions.
متن کاملSYNTHESIS AND CORROSION PROTECTION BEHAVIOR OF EPOXYTiO2-MICACEOUS IRON OXIDE NANO - COMPOSITE COATING ON St-37
The micro layers micaceous iron oxide and nano-TiO 2 were incorporated into the epoxy resin by mechanical mixing and sonication process. Optical micrographs showed that the number and diameter size of nanoparticle agglomerates were decreased by sonication. The structure and composition of the nanocomposite was determined using transmission electron microscopy which showed the presence of disper...
متن کاملبررسی خواص و مقایسه خوردگی و سایش پوششهای Zn-Ni و Zn-Ni/P
In this research, Zn-Ni and Zn-Ni/PTFE coatings were electrodeposited from sulfate-based electrolytes. Potentiodynamic polarization and electrochemical impedance spectroscopy (EIS) techniques were used to investigate the corrosion properties of the coatings. Hardness and tribological behavior of the coatings were examined by the Vickers microhardness testing machine and the pin-on-disc method...
متن کاملEffect of TiO2 nano-particles on corrosion behavior of Co-Cr alloy coatings in simulated body fluid
Co-Cr and Co-Cr/nano-TiO2 coatings were electrodeposited from Cr(III) based baths. The effect of TiO2 nano-particles incorporation on the morphology, structure, crystallite size, and preferred orientation was studied. Corrosion behavior of the composite coating was also investigated by means of polarization and electrochemical impedance spectroscopy techniques in Hanks’ si...
متن کامل