Dissolution of metal precipitates in multicrystalline silicon during annealing and the protective effect of phosphorus emitters
نویسندگان
چکیده
The degradation of the carrier lifetime in multicrystalline silicon due to the dissolution of metal precipitates during high temperature annealing is well known. This letter presents evidence indicating that the presence of phosphorus emitters during annealing can help reduce this recontamination. Part of the degradation observed is due to increased interstitial iron concentrations caused by the dissolution of iron precipitates during annealing. However, dissolution of other metals also seems to contribute to the reduced carrier lifetimes observed. © 2007 American Institute of Physics. DOI: 10.1063/1.2766664
منابع مشابه
Iron-rich particles in heavily contaminated multicrystalline silicon wafers and their response to phosphorus gettering
Heavily contaminated multicrystalline silicon wafers have been studied using a scanning synchrotron x-ray fluorescence micro-probe, revealing the presence of iron-rich particles located along grain boundaries. These particles were found to be partially dissolved and removed during phosphorus gettering treatments at 900 or 1000 ◦C for times of up to 100 min, with increased gettering efficiency a...
متن کاملStudying precipitation and dissolution of iron in multicrystalline silicon wafers during annealing
In this paper we study the changes in iron concentrations and distributions in multicrystalline silicon (mc-Si) wafers after annealing in the temperature range of 600-900 o C. The dissolved Fe distributions across mc-Si wafers are obtained by photoluminescence imaging taken before and after dissociation of FeB pairs. The results show that the precipitation of dissolved Fe, both near the grain b...
متن کاملImproved iron gettering of contaminated multicrystalline silicon by high temperature phosphorus diffusion
The efficacy of higher-temperature gettering processes in reducing precipitated iron concentrations is assessed by synchrotron-based micro-X-ray fluorescence. By measuring the same grain boundary before and after phosphorus diffusion in a set of wafers from adjacent ingot heights, the reduction in size of individual precipitates is measured as a function of gettering temperature in samples from...
متن کاملEffect of NbMo Addition on the Precipitation Behaviour of V Microalloyed Steel during Intercritical Annealing
This paper reports on the precipitation behaviour and microstructural evolution in ~20% cold rolled NbMoV and V single microalloyed low carbon steels during intercritical annealing. The microstructure and precipitation behaviour were studied by optical and scanning/transmission electron microscopy and microanalysis, X-ray diffraction technique and Vickers hardness testing. After intercritical a...
متن کاملPhosphorus diffusion gettering process of multicrystalline silicon using a sacrificial porous silicon layer
The aims of this work are to getter undesirable impurities from low-cost multicrystalline silicon (mc-Si) wafers and then enhance their electronic properties. We used an efficient process which consists of applying phosphorus diffusion into a sacrificial porous silicon (PS) layer in which the gettered impurities have been trapped after the heat treatment. As we have expected, after removing the...
متن کاملذخیره در منابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
عنوان ژورنال:
دوره شماره
صفحات -
تاریخ انتشار 2007