Inhibition of Copper Corrosion by Ethanolamine in 100 ppm NaCl
Authors
Abstract:
We study copper corrosion inhibition by ethanolamine (ETA)with (0, 0.2 ,0.3,0.4,0.5) vol.% concentrations in 100 ppm NaCl solution. This work is carried out by potentiodynamic measurements and Electrochemical Impedance Spectroscopy (EIS). The substrates' surface morphologies are examined by Scanning Electron Microscopy (SEM). ETAis characterized by NMR spectra of ETA1H and 13C and Fourier Transform InfraRed Spectroscopy (FT-IR).Quantum chemical calculation (DFT) is conducted to correlate the adsorption mechanism with ETAmolecule structure. The results show thatETA acts as a mixed inhibitor; so at 0.4 vol. %, the current density ( i ) and the polarization resistance (Rp) are respectively 0.8µA/cm2 and 28.62 Ω.cm2 with 99.78% corresponding efficiency . ETA adsorption obeys to Langmuir isotherm and takes place on the copper surface through chemical and physical mixed-type adsorption.
similar resources
inhibition of copper corrosion by ethanolamine in 100 ppm nacl
we study copper corrosion inhibition by ethanolamine (eta)with (0, 0.2 ,0.3,0.4,0.5) vol.% concentrations in 100 ppm nacl solution. this work is carried out by potentiodynamic measurements and electrochemical impedance spectroscopy (eis). the substrates' surface morphologies are examined by scanning electron microscopy (sem). etais characterized by nmr spectra of eta1h and 13c and fourier ...
full textCORROSION INHIBITION OF COPPER IN ACID MEDIUM BY DRUGS: EXPERIMENTAL AND THEORETICAL APPROACHES
The inhibition performances of nafcillin (III), methicillin (II) and penicillin G (I) on the corrosion of copper in HCl was studied and tested by weight loss, Tafel polarization, SEM, UV-vis spectrophotometry, molecular dynamics method and quantum chemical calculations. Polarization curves indicated that the studied inhibitors act as mixed-type inhibitors. The values of inhibition efficiency an...
full textInhibition of Copper Corrosion by self Assembled Amphiphiles
The advantage of nanolayers that can replace the traditional inhibitors of solids is the significant decrease in chemicals. The consequence is a lower environmental pollution. On a copper surface, special hydroxamic acid amphiphiles (CnH2n+1CONHOH, n = 9–17) were used in self-assembled molecular layers (SAM). The impact of time in SAM formation as well as the carbon chain length in the amphiphi...
full textThe Inhibition Effect of Polyethylenimine (PEI) on Pitting Corrosion of 304 Austenitic Stainless Steel in 3.5% NaCl Solution
One of the problems in the case of stainless steels is their low corrosion resistance against pitting corrosion in chloride containing environments, thereby leading to severe damage to industries. In this research, the pitting corrosion of 304 austenitic stainless steel was studied in 3.5% NaCl solution at room temperature (25˚C) by performing electrochemical measurements (containing cyclic pol...
full textCORROSION INHIBITION BEHAVIOR OF N,N′-BIS(2,4,6-TRIHYDROXYACETOPHENONE)-PROPANDIIMINE ON ST44.0 STEEL IN ALKALINE NACL SOLUTION
The inhibition behavior of N,N′-bis(2,4,6-trihydroxyacetophenone)-propandiimine (THAPP) as an environmentally friendly Salen Ligand on the corrosion inhibition of mild steel was studied in alkaline solution (pH=10) containing 3% NaCl. Measurements were carried out using electrochemical and surface techniques. The experimental results suggested that this compound was an ...
full textInhibition and promotion of copper corrosion by CTAB in a microreactor system.
We report on an optical microscopy technique for the analysis of corrosion kinetics of metal thin films in microreactor systems and use it to study the role of cetyltrimethylammonium bromide surfactant as a corrosion inhibitor in a copper-gold galvanic coplanar microsystem. A minimum in the dissolution rate of copper is observed when the surfactant concentration is approximately 0.8 mM. To expl...
full textMy Resources
Journal title
volume 35 issue 4
pages 89- 98
publication date 2016-12-01
By following a journal you will be notified via email when a new issue of this journal is published.
Hosted on Doprax cloud platform doprax.com
copyright © 2015-2023