Dielectric properties of plasma sprayed silicates subjected to additional annealing
نویسندگان
چکیده مقاله:
Several silicate materials were plasma sprayed and characterized by the authors in recent years from the point of view of their chemical and phase compositions, microstructure and mechanical as well as thermal properties. Present work is concerned with selected dielectric properties of these deposits. Synthetic mullite and steatite as well as natural olivine-forsterite were plasma sprayed using the water-stabilized plasma system WSP®. The deposits were striped-out, ground and polished to produce samples in form of plates with a smooth surface. Part of samples was later annealed in air. These samples – after coverage by metal electrodes functioning as monoblock capacitors – were tested in the alternative low voltage electric field to measure capacity and loss factor in the frequency range from 200 Hz to 1 MHz. Relative permittivity was calculated from the measured capacity. Volume resistivity was measured in the direct electric field. It is shown that the relative permittivity of plasma as-sprayed silicates is less stable compared to bulk in the whole studied frequency range. However, thermal annealing modifies the structure much closer to the sintered bulk. This is reflected also in dielectric properties. Insulating ability of plasma-sprayed silicates with and without annealing is discussed in consequence with chemical changes and phase changes induced by annealing.
منابع مشابه
Effect of morphology and nonbounded interface on dielectric properties of plasma sprayed BaTiO3 Coating
In this research, BaTiO3 thick deposit has been successfully sprayed by air plasma spray. The microstructure and dielectric properties of thick films were investigated by secondary electron microscopy (SEM) and LCR meter respectively. XRD measurement was carried out on plasma sprayed BaTiO3. The results illustrate differences in the crystal structure between plasma sprayed coatings and feed sto...
متن کاملDielectric Strontium Zirconate Sprayed by a Plasma Torch
Amultifunctional material, strontium zirconate, SrZrO3, studied in literatures as a dielectric ceramics, thermal barrier coating, proton-conductor, and luminescent material was sprayed by a water-stabilized plasma torch WSP 500. Stainless steel and plain carbon steel were used as substrates. Coatings with thickness of 1 to 2 mm were produced, whereas the substrates were preheated over 450 °C. T...
متن کاملinvestigation of gassing behavior, electric and dielectric properties of different insulating fluids.
ترانسفورماتورهای قدرت از اجزای اصلی شبکه تامین انرژی الکتریکی می باشند که عملکرد قابل اطمینان ترانسفورماتورها یکی از فاکتورهای مهم و تعیین کننده در تامین انرژی الکتریکی محسوب می شود. در نتیجه بررسی و مانیتور عملکرد ترانسفورماتورها در شبکه و همچنین عیب یابی این ترانسفورماتورها غیرقابل اجتناب و ضروری می باشد. به طور کلی عایق های مایع در صنعت فشار قوی کاربردهای متفاوتی دارند که مهمترین وظیفه آنها...
15 صفحه اولMicrostructure and Properties of Plasma Sprayed Nanostructural ZrO2 Coatings
Plasma sprayed zirconia deposits have been employed in wide applications for thermal protection. Recently, the use of nanostructural surface represents an alternative for improving the performance of these coatings. The present paper reviewed the works in this field at our research group, including synthesis of nanostructural ZrO2 powders, influence of spraying parameters on microstructure and ...
متن کاملComparative Study of Plasma Sprayed Yittria and Ceria Stabilized Zirconia Properties
Thermal Barrier Coatings are subjected to spallation and destabilization due to hot corrosion.Recently, Ceria Stabilized Zirconia (CSZ)-based TBCs have been intensively investigated for the YSZreplacement because CSZ has a much lower thermal conductivity and a higher expected thermalexpansion coefficient than those of YSZ. In this research, Yttria stabilized zirconia (YSZ) andceria stabilized z...
متن کاملمنابع من
با ذخیره ی این منبع در منابع من، دسترسی به آن را برای استفاده های بعدی آسان تر کنید
ذخیره در منابع من قبلا به منابع من ذحیره شده{@ msg_add @}
عنوان ژورنال
دوره 10 شماره 2
صفحات 105- 114
تاریخ انتشار 2017-05-01
با دنبال کردن یک ژورنال هنگامی که شماره جدید این ژورنال منتشر می شود به شما از طریق ایمیل اطلاع داده می شود.
کلمات کلیدی
میزبانی شده توسط پلتفرم ابری doprax.com
copyright © 2015-2023